Spring & cable repair · Ponca City
Garage door spring repair in Ponca City
That bang from the garage wasn't the water heater. When a torsion spring lets go, the door becomes dead weight - don't fight it, and don't let anyone sell you a whole new door over a $250 part.
What actually happened to your door
The springs - not the opener - do the lifting. A sixteen-foot steel door weighs 150 to 250 pounds, and the torsion spring above the opening counterbalances nearly all of it. Springs are rated in cycles (one open-and-close each), and most builder-grade springs are 10,000-cycle parts: eight to twelve years of normal use. Cold snaps finish off tired springs, which is why Kay County's first real January norther is our busiest spring week of the year.
When one lets go, the opener can't lift the dead weight. Forcing it strips the opener's gear and turns a spring bill into a spring-plus- opener bill - so unplug it, leave the door down, and call.
What the visit looks like
- We measure the old spring (wire size, length, inside diameter) and the door's real weight - springs are sized to the door, not guessed from a chart
- Both springs replaced on two-spring doors unless you tell us otherwise; cables, bearings, and drums inspected while the shaft is unloaded
- The door is balanced and cycle-tested before we leave - it should hold still at half-open with the opener disconnected
- High-cycle springs offered as a priced option, not an upsell speech - the math is on paper next to the standard part
Cables ride along
Lift cables fray at the bottom bracket where Oklahoma grit and moisture collect. A frayed cable usually announces itself by snapping the same week a spring goes, so we check both - and if your door is sitting crooked with a cable in a pile, that's an off-track call: stop using the door entirely.
Door too heavy to lift? That's the spring. Call now.
Spring questions, answered straight
How do I know it’s the spring that broke?
The classic signs: a single loud bang from the garage (often at night or in a cold snap), a door that suddenly weighs a hundred pounds when you try to lift it, a visible gap in the coil above the door, or an opener that strains and gives up. Any one of those almost always means a snapped torsion spring.
What does spring replacement cost in Ponca City?
A single torsion spring on a standard door typically runs $180-$280 installed; a pair on a two-car door $220-$400. Extension springs (common on older Ponca City garages) run similar. You get the exact figure in writing before we wind anything - the full table is on the pricing page.
Should I replace both springs if only one broke?
Almost always yes on a two-spring door. Both springs have flexed the same number of cycles, so the survivor is usually weeks from the same failure - and you’d pay a second trip charge to have it swapped later. We’ll show you the wear before you decide; it’s your call, priced both ways.
Can I replace a garage door spring myself?
We’d rather lose the job than have you try. A wound torsion spring stores enough energy to break an arm, and winding bars are not a YouTube skill. It’s the one garage door repair we flatly tell neighbors not to attempt - here’s the honest explanation why.
How long does the repair take?
About an hour for a standard torsion spring swap once we’re in the driveway, including new bearings if the shaft needs them and a full balance check afterward. Most spring calls in Ponca City are done the same day you call.
Free written quote
Describe the door. We’ll put a price on paper.
Spring went off like a rifle shot? Opener hums but nothing moves? Door sitting crooked since the last windstorm? Two sentences is plenty - we’ll call back with a straight answer and a written number. Rather just talk? (580) 382-7992.
- The number is on paper before the toolbox opens - parts, labor, and haul-away in one figure, not a "starting at" teaser
- Name the symptom on the phone and we can usually tell you the likely part and its honest price range before anyone rolls
- Your call stays in Kay County - it is never auctioned off to three strangers the way the big lead sites do it